2024-01-28 BMWs and Parts Loaded for Murphys

published by dcarver on Wed, 01/31/2024 - 12:47

Forums:

Both bikes going back to Murph at Murph's BMW for some work.

In the trailer ready to rock.

I like this pic.

Brand new parts, if needed.

A little bit of $$$ there.

R69S work list

LHS cylinder base leak (recall it has gouges, we tried multiple layers of gaskets, but it still leaks.

Carb work, it floods, probably a float

Gas tank interior – overspray. Clean.

Major tune up. Points, charging system, brakes, drive train, the whole enchilada. Make it super reliable and trust worthy.

Install aftermarket side stand. Sacrilege, I know..

R60/2 work list

Replace front, rear brake linings with ‘glued’, not riveted linings. The fronts howl and the rear was overheated.

Adjust front brake linkage

Fix leak from drive shaft tube into final drive

Determine if ‘shelf’ leak is from trans or engine. Fix.

New driveline boot

4 new shocks. Keep old ones. Put 4 best of the used on the 69s.

New pushrod rubbers

Carb intake boots Will do

Full tune up - ignition, fueling, everything Will do

Check, Adjust key switch for headlight position. Think I fixed it.. dirty contact.

Major tune up. Points, charging system, brakes, drive train, the whole enchilada. Make it super reliable and trust worthy.

Install turn signals

Install deep sump oil pan /2 if it fits. It may only fit r69s. Not sure.

Install new foot peg rubbers. Keep old ones.

Candy Butt Association